JHM Remapping

JHM Remapping Contact information, map and directions, contact form, opening hours, services, ratings, photos, videos and announcements from JHM Remapping, Automotive repair centre, The Garage, Caldervale Road, Wakefield.

JHM offer custom bespoke ECU remapping & chip tuning, EGR, DPF, OPF, SCR solutions adblue removal, DTC code removal, swirl flap removal
Custom tuning for hybrid turbos, injector scaling, map sensor calibration

complete diagnostic capabilities

Greg Lambert Greg Lambert Racing JHM Racing
05/03/2024

Greg Lambert Greg Lambert Racing JHM Racing

Had the pleasure of sorting clutch issues out on Mikes rather beautiful Cosworth powered MK1 Escort❀️Running an AP 6 pad...
28/06/2023

Had the pleasure of sorting clutch issues out on Mikes rather beautiful Cosworth powered MK1 Escort❀️

Running an AP 6 paddle and hydraulic pedal setup up, the clutch had been replaced only 1500 miles ago anf now the pedal was super high and very little movement on the pedal between disengagement and engagement of the clutch.
Checking free play on the release bearing we had just over 4mm so knew something wasn't quite right.
With the gearbox, clutch and flywheel removed we measured the stack height and found it to be around 3mm too short, so we set about measuring each component individually and found the flywheel had been skimmed multiple times way past it's permissible limits.

We fitted a new flywheel and a new pressure plate, re installed and hey presto the clutch pedal was exactly where it should be.

VAG PD130 - JHM spec camshaft, our own specification, Nitrided lifters, all new genuine stretch bolts and cam bearings, ...
14/10/2021

VAG PD130 - JHM spec camshaft, our own specification, Nitrided lifters, all new genuine stretch bolts and cam bearings, complete INA timing belt and water pump kit,

huge gains in torque, allowing the hybrid turbo to spool up much quicker alowing peak boost to be reached 800rpm earlier in the rev range, making the best out the hybrid turbo πŸ‘Œ

08/10/2021

JHM panda 100hp project video

Centre res delete plus a 4-2-1 tubular manifold..... it's a little on the loud side now πŸ€ͺπŸ˜πŸ™‰

The new little JHM project carPanda 100hpGot may plans in the pipe line so keep tuned for alot more with thisFirstly we ...
08/10/2021

The new little JHM project car
Panda 100hp

Got may plans in the pipe line so keep tuned for alot more with this

Firstly we have carried out a couple of little styling mods
Abarth front and rear badges
Wind deflectors
Abarth wheel centre badges

Rear beam swapped out with an Abarth 695 beam 40mm wider than stock
Whilst carrying out the beam swap we fitted poweflex beam bushes

Exhaust, centre res delete plus a 4-2-1 tubular manifold..... it's a little on the loud side now πŸ€ͺ😁
Video to follow!

Mini 1.6 in today with running issues and management light onDiagnostic read showed cam to crank correlation faults and ...
08/10/2021

Mini 1.6 in today with running issues and management light on
Diagnostic read showed cam to crank correlation faults and exhaust VVT solenoid fault
Further scope testing prooved the vvt solenoid was at fault

To further investigate the cam to crank correlation faults we removed the rocker cover to be greeted with the usual broken timing chain guides.

Full timing chain kit replacement including VVT hubs and replacement VVT solenoid
Removal of the sump to find broken timing chain guide bebris blocking the oil pick up pipe, cleaned out, oil filter and oil change done

VVT vanos adaptations reset and relearned.

Car is now running perfect πŸ˜ŽπŸ‘Œ

Golf R in for a low drone centre res delete pipeNice subtle mod for a deeper tone πŸ‘Œ
08/10/2021

Golf R in for a low drone centre res delete pipe
Nice subtle mod for a deeper tone πŸ‘Œ

Insignia 2.0 CDTi 140bhp in with DPF issues custom tune + DPF and EGR removal solution
08/10/2021

Insignia 2.0 CDTi 140bhp in with DPF issues custom tune + DPF and EGR removal solution

1957 Bentley S1 Sports Saloon, James Young full aluminim body, 1 of only 27 ever made😎😎😎In for gearbox mount and diagnos...
07/10/2021

1957 Bentley S1 Sports Saloon, James Young full aluminim body, 1 of only 27 ever made😎😎😎

In for gearbox mount and diagnosing a knocking noise on start up, diagnosed as the bendix drive on the starter motor

Absolute pleasure to work on this truly priceless and stunning classic

Stunning Bentley Turbo R today for Air con regas πŸ”₯❀
23/07/2021

Stunning Bentley Turbo R today for Air con regas πŸ”₯❀

Ryans rather nice type R in today for bembo discs and pads replacing πŸ”₯
19/07/2021

Ryans rather nice type R in today for bembo discs and pads replacing πŸ”₯

This was an interesting one, customer purchased this car from a dealer, car ran fine on their way home, next day mil on ...
18/07/2021

This was an interesting one, customer purchased this car from a dealer, car ran fine on their way home, next day mil on and running rough, tge dealer didn't want to know

We happily took on this job, upon investigation we found x2 poor injectors, but also evidence that someone had been messing around previously, wiring bared back and not re insulated, this is not the way to go with testing injector wiring and signals, oscilloscope and amps clamp are the only way to go and is also none intrusive, meaning no need to bare the wiring back, when needing to check continuity we simply used back probes, again none intrusive.
Our investigations showed the vehicle had been sold with the issue and the dealer then agreed to repair the car at no cost to the customer.... result!

Address

The Garage, Caldervale Road
Wakefield
WF15PH

Opening Hours

Monday 8:30am - 7:30pm
Tuesday 8:30am - 7:30pm
Wednesday 8:30am - 7:30pm
Thursday 8:30am - 7:30pm
Friday 8:30am - 6pm

Telephone

+447747701480

Alerts

Be the first to know and let us send you an email when JHM Remapping posts news and promotions. Your email address will not be used for any other purpose, and you can unsubscribe at any time.

Contact The Business

Send a message to JHM Remapping:

Share