30/10/2016
ADBLUE REMOVAL SERVICE FROM EAGLE - TEC
How The SCR System Works
AdBlue is the registered trademark for AUS32 (Aqueous Urea Solution 32.5%) and is used in a process called Selective Catalytic Reduction (SCR) to reduce emissions of oxides of nitrogen from the exhaust of diesel vehicles. AdBlue is used by an advanced pollution control technology installed in the exhaust system called Selective Catalytic Reduction or SCR. SCR systems work by reacting AdBlue with the harmful NOX (nitrogen oxide) gases in the exhaust to form harmless water and nitrogen. All European truck manufacturers currently offer SCR equipped models, and the future Euro 5 and future Euro 6 emission standards are set to reinforce the demand for this technology. The driver must ensure that he always has an adequate supply of AdBlue in the tank because if a truck or bus with an SCR system is operated without AdBlue then, beside the risk of damaging the SCR system, in most of the cases the vehicle stops running or goes into LIMP mode! Moreover, another important aspect is the consumption that, on average, is about 5% of diesel use, therefore for motorway driving you will use about 1.5 litres per 100 km (that means in any case a remarkable amount of extra money every year. SCR systems are also very sensitive to potential chemical impurities in the urea solution; therefore,it is essential to maintain high standards of AdBlue quality according to the ISO 22241 standard. Many companies and individuals trying to reduce the enormous cost Adblue adds to the running of their fleet have tried buying cheaper AdBlue from resellers or in some case adding water to the tank to try and dilute the solution. AdBlue have announced that they will not offer warranty if the operator has failed to use genuine AdBlue, or if the substance has been diluted. Also manufacturers of the trucks will not honour any warranty on the system if there are any signs of contamination in the tank, this can cost over £5000 to replace the system.
What We Can Do To Help….
If you would like to switch off the Adblue system on your truck because the system has failed so badly that even the dealer can not fix it then we can reprogram your ECU to do this. Our Adblue removal service is fully guaranteed and will never cause you a problem again. We offer this service fully mobile across the whole London, The South & SE. The benefits of this are, No more truck downtime while the truck is either in LIMP mode or being taken in and out of the dealer while they are ‘trying’ to fix the problem. No more expensive repair costs when the Adblue system becomes faulty or contaminated. The vehicle will no longer consume Adblue which will also save money. This process of ECU reprogramming will not leave any traces of the system being inactive or any fault codes on the dash or in the ECU so you can take it into the dealers for service and they won’t be able to detect that its been disabled. It will even still pass MOT as the only check is, “Does the Adblue warning light illuminate and go out when the engine is started” Which it will do. Whilst we are reprogramming the ECU on your truck to switch off the Adblue system we can also remap the engine which will change the way in which your engine burns it’s fuel resulting in better performance, more torque and efficiency which will save you approximately 10-15% of your Diesel consumption also.
